[1]乔 燕,孙传智,李爱群,等.高应变率下HRB600高强钢筋力学性能试验研究[J].防灾减灾工程学报,2019,39(06):905-911.[doi:10.13409/j.cnki.jdpme.2019.06.004]
 QIAO Yan,SUN Chuanzhi,LI Aiqun,et al.Experimental Study on Mechanical Properties of High Strength Steel Bar HRB600 under High Strain Rate[J].Journal of Disaster Prevention and Mitigation Engineering,2019,39(06):905-911.[doi:10.13409/j.cnki.jdpme.2019.06.004]
点击复制

高应变率下HRB600高强钢筋力学性能试验研究()
分享到:

防灾减灾工程学报[ISSN:1672-2132/CN:32-1695/P]

卷:
39卷
期数:
2019年06期
页码:
905-911
栏目:
论文
出版日期:
2019-12-31

文章信息/Info

Title:
Experimental Study on Mechanical Properties of High Strength Steel Bar HRB600 under High Strain Rate
文章编号:
1672-2132(2019)06-0905-07
作者:
乔 燕1 孙传智1 李爱群23 缪长青2 朱方之1
(1.宿迁学院建筑工程学院, 江苏 宿迁 223800; 2.东南大学土木工程学院, 江苏 南京 210096; 3.北京建筑大学土木与交通工程学院, 北京 100044)
Author(s):
QIAO Yan 1 SUN Chuanzhi 1 LI Aiqun23 MIAO Changqing2 ZHU Fangzhi1
(1.School of Civil Engineering and Architecture, Suqian 223800,China; 2.School of Civil Engineering,Southeast University,Nanjing 210096,China; 3.School of Civil and Transportation Engineering, Beijing University of Civil Engineering and Architecture,Beijing 100044,China)
关键词:
高强钢筋 高应变率 力学性能 强度提高系数 动态本构关系
Keywords:
high strength bar high strain rate mechanical properties improvement coefficient of strength dynamic constitutive model
分类号:
TU375.4
DOI:
10.13409/j.cnki.jdpme.2019.06.004
文献标志码:
A
摘要:
钢筋混凝土结构抗震分析中应该采用钢筋材料的动态塑性本构模型,HRB600高强钢筋作为新一代建筑钢材,尚无其在高应变率下的力学性能研究。首先进行了HRB600高强钢筋拉伸力学性能试验, 得到了不同应变率下的HRB600高强钢筋力学性能数据,屈服强度最大提高11.5%,极限强度最大提高8.9%,然后拟合得到HRB600高强钢筋在高应变率下的强度提高系数表达式。研究结果表明:随着应变率的增大,钢筋的屈服强度和极限强度均得到提高; 在相同应变率条件下,钢筋屈服强度动力提高系数大于极限强度动力提高系数; 相比较低强度钢筋,应变率敏感性明显低于HPB235、HRB335及HRB400,但与HRB500钢筋相差较小,而极限强度应变率敏感性明显高于低强度钢筋; 基于试验数据得到的HRB600高强钢筋在高应变率下的动态塑性本构模型,与试验值吻合较好。研究成果可作为HRB600高强钢筋混凝土结构抗震评估的依据。
Abstract:
The dynamic plastic constitutive model of steel rebar should be used in seismic analysis of reinforced concrete structures. As a new generation steel rebar, there is no published research on the mechanical properties of HRB600 under high strain rate. In this paper, the tensile mechanical properties of HRB600 under different strain rates were studied, and the mechanical properties of HRB600 under different strain rates were obtained. The yield strength increased by 11.5% and the ultimate strength increased by 8.9%. The expression of improvement coefficient of HRB600 under high strain rate was proposed. The results show that the yield strength and ultimate strength of reinforcement improve with the increase of strain rate. Under the condition of the same strain rate, the improvement coefficient of yield strength is greater than that of ultimate strength. Compared with low strength steel, the sensitivity of strain rate of HRB600 is significantly lower than that of HPB235, HRB335 and HRB400. But there is little difference between HRB600 and HRB 500. The ultimate strain rate sensitivity of HRB600 is significantly higher than that of the low strength steel bars. On the basis of the experimental data, a dynamic plastic constitutive model of HRB600 under high strain rate is obtained. The research results can be used as the basis for seismic evaluation of HRB600 high strength reinforced concrete structure.

参考文献/References:

[1] Shing P S B, Mahin S A. Rate-of-loading effects on pseudodynamic tests [J]. Journal of Structural Engineering, 1988,114(11):2 403-2 420.
[2] 李 敏,李宏男.建筑钢筋动态试验及本构模型[J]. 土木工程学报, 2010,43(4):70-75. Li M, Li HN. Dynamic test and constitutive model for reinforcing steel[J]. China CivilEngineering Journal, 2010,43(4):70-75.(in Chinese)
[3] 林 峰,顾祥林,匡昕昕,等.高应变率下建筑钢筋的本构模型[J].建筑材料学报,2008,11(1):14-20. Lin F, Gu X L, Kuang X X, et al. Constitutive models for reinforcing steel bars under highstrain rates [J]. Journal of Building Materials, 2008,11(1):14-20.(in Chinese)
[4] 林 峰,董 羽,顾祥林. 高强度建筑钢筋HRB500的动力本构模型[J].建筑材料学报,2014,17(4):592-597. Lin F, Dong Y, Gu X L. Dynamic constitutive models for highstrength reinforcing steel bar HRB500[J]. Journal of Building Materials, 2014,17(4):592-597.(in Chinese)
[5] 黄晓莹,陶俊林.三种建筑钢筋材料高应变率下拉伸力学性能研究[J].工程力学,2016,33(7):184-189. Huang X Y,Tao J L. Tensile mechanicalproperties research of three construction steel bars in high strain rate[J].Engineering Mechanics,2016,33(7):184-189.(in Chinese)
[6] 王德斌,李宏男.应变率对钢筋混凝土柱动态特性的影响[J].地震工程与工程振动,2011,31(6):67-72. Wang D B, Li H N. Effects of strain rate on dynamic behavior of reinforced concrete column [J].Journal of Earthquake Engineering and Engineering Vibration, 2011,31(6):67-72.(in Chinese)
[7] 王文明,王德斌,李宏男,等. 应变率对钢筋混凝土框架结构地震作用下灾变过程影响研究[J]. 振动与冲击, 2014,33(1):130-136. Wang W M, Wang D B,Li H N,et al. Effect of strain rate on the failure processof reinforced concrete frame structure under earthquake[J]. Journal of Vibration and Shock, 2014,33(1):130-136.(in Chinese)
[8] Li M, Li H. Effects of strain rate on reinforced concrete structure under seismic loading[J]. Advances in Structural Engineering, 2012,15(3):461-476.
[9] Zhang H, Li H N,Wang Z. Study on strain rate effect in high-Rise reinforced concrete shear wallstructure[J]. Advances in Structural Engineering, 2011, 243-249:5 854-5 857.
[10] 张 皓,李宏男.应变率对钢筋混凝土剪力墙动态性能的影响[J].防灾减灾工程学报,2010,30(3):303-308. Zhang H, Li H N. Effects of strain rate on dynamic behavior of reinforced concrete shear wall[J]. Journal of Disaster Prevention & Mitigation Engineering, 2010,30(3):303-308.(in Chinese)
[11] Deng L, Cai C S. Bridge model updatingusing response surface method and genetic algorithm [J].Journal of Bridge Engineering,2010,15(5):553-564.
[12] 李艳艳,李晓清,苏恒博. 600MPa高强钢筋与混凝土的粘结锚固性能试验研究[J].土木建筑与环境工程,2017,39(2):19-25. Li Y Y,Li XQ,Su H B. Experimental analysis of bond-anchorage properties between 600 MPa high strength reinforcement and concrete[J]. Journal of Civil, Architectural & Environmental Engineering, 2017,39(2):19-25.(in Chinese)
[13] 李 强,戎 贤,李艳艳.配置HRB600钢筋的部分预应力混凝土梁疲劳试验研究[J].建筑结构,2016,46(2):8-12. Li Q, Rong X, Li Y Y. Experimental study on fatigue behavior of partially prestressed concrete beams with HRB600 steel bars[J]. Building Structure, 2016,46(2):8-12.(in Chinese)
[14] 郭 蓉,朱 凯.配置600 MPa级高强钢筋混凝土剪力墙的抗震性能研究[J].工业建筑, 2017,47(6):34-39. Guo R, Zhu K. Experimental research on seismic behavior of RC shear wall with 600 megapascal high-strength reinforced bars[J]. Industrial Construction, 2017,47(6):34-39.(in Chinese)
[15] 戎 贤,段微微,王 浩.配置600MPa级高强钢筋T形柱抗震性能试验研究[J].土木建筑与环境工程,2017,39(2):148-154. Rong X, Duan W W, Wang H. Experimental analysis of seismic behavior of 600MPa RC T-shaped columns[J]. Journal of Civil,Architectural& Environmental Engineering, 2017,39(2):148-154.(in Chinese)
[16] Johnson GR, Cook W H. Fracture characteristics of three metals subjected to various strains, strains rates, temperature and pressure[J]. Engineering Fracture Mechanics, 1985, 21(1):31-48.
[17] Mousavi A S H, Madaah-Hosseini H R, BahramiA. Flow stress optimization for 304 strainless steel under cold and warm compression by artificial neural network and genetic algorithm[J]. Materials & Design, 2007,28(2):609-615.
[18] Bammann D J. Modeling temperature and strain rate dependent large deformation of metals[J]. Applied Mechanics Review, 1990,43(5):S312-S319.
[19] Bodner S R, Parton Y. Constitutive equations for elastic-visco-plastic strain-harding materials[J].Journal of Applied Mechanics, 1975, 42(2):385-389.
[20] 张长清,谢兰生, 陈明和,等. 高应变率下TC4-DT钛合金的动态力学性能及塑性本构关系[J]. 中国有色金属学报, 2015, 25(2):323-329. Zhang Ch Q,Xie L Sh,Chen M H,et al. Dynamic mechanical property and plastic constitutive relation of TC4-DT Ti alloy under high strain rate[J]. The Chinese Journalof Nonferrous Metals, 2015,25(2):323-329.(in Chinese)

相似文献/References:

[1]徐智敏,韩重庆,许清风,等.粘贴角钢加固受火后高强钢筋混凝土连续T形梁的试验研究[J].防灾减灾工程学报,2016,36(03):471.[doi:10.13409/j.cnki.jdpme.2016.03.023]
 XU Zhimin,HAN Chongqing,XU Qingfeng,et al.Experimental Research on Fire-damaged RC Continuous T-beam with High-strength Rebar Strengthened with Steel Angle[J].Journal of Disaster Prevention and Mitigation Engineering,2016,36(06):471.[doi:10.13409/j.cnki.jdpme.2016.03.023]

备注/Memo

备注/Memo:
收稿日期:2018-05-07; 修回日期:2018-11-24基金项目:江苏省六大人才高峰项目(2015-JZ-019)、宿迁市千名拔尖人才培养工程项目(2017)、江苏省“333工程”培养资金项目(BRA2017273)、江苏省建设系统科技项目(2017ZD117)资助作者简介:乔 燕(1976-),女,副教授,硕士。主要从事工程结构抗震和大跨桥梁承载力评估方面的研究。Email:sqqiaoyan@163.com
更新日期/Last Update: 2019-12-25